16 août 2019 | International, Aérospatial

A-10 Enhanced Wing Assembly Replacement Program Comes To An End

A-10s Get New Wings

Workers at the Ogden Air Logistics Complex at Hill Air Force Base have installed the last of 173 new wings on A-10 Thunderbolt II aircraft, finalizing a project that started in 2011 with aircraft 80-0173. The ALC's 571st Aircraft Maintenance Squadron swapped wings on 162 A-10s as part of the A-10 Enhanced Wing Assembly replacement program. The remaining 11 were installed at Osan Air Base in the Republic of Korea. The new wings are expected to last for up to 10,000 equivalent flight hours without a depot inspection. In addition, a better wire harness design was created for easier wing removal and to lessen the chance of damaging the wing during the process.

“From a warfighter point of view, bringing this program to a successful conclusion was a significant accomplishment for the entire enterprise team,” said Stephen Zaiser, 571st AXMS director. Working on an aircraft that has been flying for nearly 40 years wasn't without challenges. The modifications included having to make new parts for the fuselage and having to bring other A-10 parts up from the 309th Aerospace Maintenance and Regeneration Group at Davis-Monthan Air Force Base, Arizona.

“At the end of the program, making sure we had all the pieces and parts that we needed to make that happen required a really significant team effort,” Zaiser said. “I think the fact that we produced the aircraft so successfully is a testament to the whole team, the special program office, Boeing and others that were a part of making it all work.”

Lt. Col. Ryan Richardson, 514th Flight Test Squadron commander and A-10 test pilot, flew the functional check flight on the last A-10 to receive the new wings to deem the aircraft airworthy.

“It flew great and passed all the FCF checks,” Richardson said. “It's unusual to have an airplane in production for as long as this one was and have it come out and fly as well as this one did.”

Introduced into the U.S. Air Force aircraft inventory in 1976, the venerable A-10 is the only production-built aircraft for close air support. The aircraft was made to fly close to the ground in support of friendly ground troops, drop heavy loads of weapons, attacks armored vehicles and tanks, and can be called in to attack enemy ground forces. With heavy stresses put on the wings over the weapon system's lifetime and with its full-service life still unknown, the Air Force decided to replace some of the fleet's wings in order for the weapon system to remain airworthy. In 2007, Boeing was awarded a $1.1 billion contract to build replacement wings at its Macon, Georgia, plant that will allow the aircraft to continue flying into the late 2030s.

“The A-10 Special Program Office, in partnership with the Ogden ALC, is poised to keep the aircraft flying for the foreseeable future,” said Michael Hackett, A-10 SPO chief engineer.

http://www.aero-news.net/index.cfm?do=main.textpost&id=e3fe8bb4-6d74-4d69-845e-d6e204fcfbe7

Sur le même sujet

  • India’s new defense budget falls way short for modernization plans

    6 février 2019 | International, Aérospatial, Naval, Terrestre, C4ISR, Sécurité, Autre défense

    India’s new defense budget falls way short for modernization plans

    By: Vivek Raghuvanshi NEW DELHI – India's defense budget for 2019 included a marginal 6.87 percent bump to $49.68 billion, which is unlikely to meet modernization demands or ‘Make in India' manufacturing increases. Out of the total allocation, $16.91 billion has been set aside to buy new weapons and other military hardware, compared to $14.68 billion in the previous financial year. But not accounted for are the liabilities, say some defense analysts, which could chip away at available funds. “As of now, one doesn't know about the extent of committed liabilities to be able to say how much money will be available for new purchases,” said Amit Cowshish, former financial advisor for the Ministry of Defence acquisition. "But it can be said with reasonable certainty that the allocation must be much less than the requirement projected by the ministry. That being the case, the ministry will have to make do with whatever money they have got, just the way they have been managing in the past.” India's defence budget is more than five times that of Pakistan, pegged at $9.6 billion — barely enough to maintain its basic operational capability. Presenting the interim budget for 2019-20 in parliament, Union Minister for Finance and Corporate Affairs Piyush Goyal said additional funds, if necessary, would be provided to secure India's borders and maintain its defense preparedness. Under capital outlay, the Army was granted $4.60 billion and the Navy granted $3.61 billion — both nearly flat compared to the year before. The Indian Air Force was allocated $6.14 billion, combared to $5.58 billion in the previous year. One MoD official said the majority of funds will go towards past committed liabilities for Rafale fighters, S-400 missile systems, warships and helicopters. Still, the fact that the budget saw an increase is noteworthy to some. “The allocation for defense, which for the first time has crossed the $49 billion threshold is encouraging," said Baba Kalyani, chairman of leading private sector defense enterprise Bharat Forge Ltd. In terms of manufacturing, "we hope that ‘Make in India' will result in a greater role for the private industry in this critical sector of the country's economy.” Cowshish is less encouraged, seeing very few noteworthy programs on the horizon. “It doesn't seem likely that many big contracts for fighters, helicopters, submarines, etc. will get concluded in the coming year," he said. "This is not because of paucity of funds but on account of the fact that none of these procurement proposals are likely to reach anywhere near the contract conclusion stage any time soon. “ https://www.defensenews.com/global/asia-pacific/2019/02/05/indias-new-defense-budget-falls-way-short-for-modernization-plans/

  • Navy aims to hasten remaining Columbia sub work in case of test delays

    23 octobre 2023 | International, Naval

    Navy aims to hasten remaining Columbia sub work in case of test delays

    To hedge against first-in-class test delays, the Navy wants to build back a schedule buffer for the District of Columbia.

  • Canadian military fears maintenance issues will plague equipment sent to Latvia

    29 décembre 2024 | International, Terrestre

    Canadian military fears maintenance issues will plague equipment sent to Latvia

    DND acknowledged a lack of storage and maintenance facilities at Camp Adazi in Latvia, but said fixes are underway.

Toutes les nouvelles